全国服务热线:15953195999
产品中心
您所在的位置:首页-新闻中心-常见问题-二手电动叉车的日常维护要注意什么?

二手电动叉车的日常维护要注意什么?

来源:/ 日期:2021-10-19 发布人:hangong

1、对电动叉车进行全面的清洗工作,重点要清洗这些部位:货叉架及门架滑道、发电机及起动器、蓄电池电极叉柱、水箱、空气滤清器。

1. Comprehensively clean the electric forklift, focusing on cleaning these parts: fork frame and gantry slide, generator and starter, battery electrode fork column, water tank and air filter.
2、要对各个部位的牢固情况进行全面的检查,要重点留意这几个部位:货叉架支承、起重链拉紧螺丝、车轮螺钉、车轮固定销、制动器、转向器螺钉。
2. Conduct a comprehensive inspection on the firmness of all parts, focusing on these parts: fork support, lifting chain tension screw, wheel screw, wheel fixing pin, brake and steering gear screw.
3、检查电动叉车的转向器的可靠性、灵活性。
3. Check the reliability and flexibility of the steering gear of the electric forklift.
4、检查电动叉车渗漏情况,重点是:各管接头、柴油箱、机油箱、制动泵、升降油缸、倾斜油缸、水箱、水泵、发动机油底壳、变矩器、变速器、驱动桥、主减速器、液压转向器、转向油缸。
4. Check the leakage of electric forklift, focusing on: pipe joints, diesel tank, engine oil tank, brake pump, lifting cylinder, tilt cylinder, water tank, water pump, engine oil pan, torque converter, transmission, drive axle, main reducer, hydraulic steering gear and steering cylinder.
5、电动叉车轮胎气压检查:不足应补充至规定值,确认不漏气。检查轮胎接地面和侧面有无破损,轮辋是否变形。
5. Inspection for tire pressure of electric forklift: if it is insufficient, it shall be supplemented to the specified value to confirm that there is no air leakage. Check whether the tire ground and side are damaged and whether the rim is deformed.
济南8040网站威尼斯
6、电动叉车制动液、水量检查:查看制动液是否在刻度范围内,并检查制动管路内是否混入空气。添加制动液时,防止灰尘、水混入。向水箱加水时,就使用清洁自来水,若使用了防冻液,应加注同样的防冻液。水温高于70℃时,不要打开水箱盖,打开盖子时,垫一块薄布,不要带手套拧水箱盖。
6. Inspection of brake fluid and water volume of electric forklift: check whether the brake fluid is within the scale range and whether air is mixed in the brake pipeline. When adding brake fluid, prevent dust and water from mixing. When adding water to the water tank, use clean tap water. If antifreeze is used, add the same antifreeze. When the water temperature is higher than 70 ℃, do not open the water tank cover. When opening the cover, pad a thin cloth and do not screw the water tank cover with gloves.
7、二手电动叉车发动机机油量、液压油、电解液检查:先拔出机油标尺,擦净尺头后插入再拉出检查油位是否在两刻度线之间。工作油箱内油位应在两根刻度线之间;油太少,管路中会混入空气,太多会从盖板溢出。电瓶电解液也同样要处在上下刻度线之间,不足则要加蒸馏水到顶线。
7. Inspection of engine oil, hydraulic oil and electrolyte of used electric forklift: first pull out the oil dipstick, wipe the head of the dipstick, insert it, and then pull it out to check whether the oil level is between the two graduation marks. The oil level in the working oil tank shall be between two scale marks; If there is too little oil, air will be mixed in the pipeline, and too much oil will overflow from the cover plate. The battery electrolyte shall also be between the upper and lower scale lines. If it is insufficient, distilled water shall be added to the top line.
8、电动叉车的制动踏板、微动踏板、离合器踏板、手制动检查:踩下各踏板,检查是否有异常迟钝或卡阻。二手电动叉车手制动手柄的作用力应小于300N,确认手制动安全可靠。
8. Inspection of brake pedal, inching pedal, clutch pedal and hand brake of electric forklift: press each pedal to check whether there is abnormal retardation or jamming. The force of the second-hand electric fork driver's brake handle shall be less than 300N to confirm that the hand brake is safe and reliable.
9、电动叉车的皮带、喇叭、灯光、仪表等检查:检查二手电动叉车皮带松紧度是否符合规定,没有调整余量或破损有裂纹,须更换;喇叭、灯光、仪表均应正常有效。
9. Inspection of belt, horn, light, instrument, etc. of electric forklift: check whether the tightness of the belt of second-hand electric forklift meets the regulations, there is no adjustment allowance or damage and cracks, and it must be replaced; The horn, light and instrument shall be normal and effective.
10、 放去机油滤清器沉淀物。
10. Drain the oil filter sediment.
济南8040网站威尼斯为您提供了以上的精彩内容,更多的精彩内容请点击进入我们的网站:http://www.sdjnltqf.com 我们后续会有更多的内容等您查看。
Jinan used forklift provides you with the above wonderful contents. For more wonderful contents, please click to enter our website: http://www.sdjnltqf.com  We will have more content for you to check later.

8040网站威尼斯
地址:山东省济南市章丘区龙山街道济青路龙山段南侧1幢   电话:15953195999
网站:/   备案号:鲁ICP备14018186号-1  技术支持:网站建设·推广运营

鲁公网安备 37011202000702号

 

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】

8040网站威尼斯_【唯一授权网站】